Extraction Cleaning · Lutterworth
From the the High Street inns to the Magna Park canteens, Lutterworth cooks over open flame - and a greased-up canopy, filter and fan pull badly, run hot and add fire risk. We strip and degrease the whole system, canopy to fan, and certify it fire-safe.
Tell us about the canopy, filters and ducting in your Lutterworth kitchen and get a guide price straight away - no measuring, no site visit, no waiting.
Try the cost calculatorFrom the High Street inns to the Magna Park canteens, Lutterworth runs its cooklines hard, and each one faces the same thing - grease building on the canopy service after service. The settings change; the grease does not.
In a food economy of 774 rated premises, a Lutterworth line loads canopy, filters and fan steadily until the grease sets - and then the hood stops capturing, the kitchen turns hot and smoky, and the fan sits as a fire risk over a live flame. We degrease the whole system so draw and fire safety come back together.
Swapping filters treats the symptom; grease in the canopy, plenum and fan is what actually strangles the airflow. Clean the lot together and the cookline captures again, the kitchen runs cooler, and the fire risk over a live line comes down with it.
It is measured and evidenced to TR19 Grease, with the fan the tell: when a Lutterworth kitchen goes hot and smoky, it is usually grease unbalancing the impeller, not the filters.
The standard on a commercial canopy. We strip, soak and scrape them back, and flag any that are warped or missing - the gap a warped filter leaves lets grease straight into the plenum.
Common on lighter lines and older canopies, and quick to clog solid. We clean what you run and advise where a baffle filter would serve a heavy frying line better.
On enclosed or recirculating systems. We service the stages, check the seals and tell you what needs replacing rather than cleaning.
Many cooklines carry a wet-chemical system built into the canopy. We degrease the filters, canopy and fan without disturbing the nozzles or detection - so you keep both defences.
Where a gas interlock ties the cookline to the extract, we work around it and leave it functioning, so the line cannot fire without the extraction running.
We check and clear accessible fire dampers in the run, so a damper that has to close in a fire is not seized solid with grease.
Typical jobs we handle, by sector and area - representative of the work we do, not named clients.
At a day nursery in Lutterworth, preparing meals for the under-fives, grease had built from the baffles back to the impeller and the canopy no longer pulled the line clear. We stripped the baffles and canopy, cleaned the accessible duct, and degreased the fan housing and blades working around service. The pull and the fire protection were back, with a certificate and photographs.
At a hotel in Lutterworth, running breakfast and dinner service for guests, grease had built from the baffles back to the impeller and the canopy no longer pulled the line clear. We degreased the whole system - filters, canopy, plenum, fan and the accessible duct between services. The pull and the fire protection were back, with a certificate and photographs.
We check the canopy, filters and fan, note the airflow and grease loading, and agree scope around your service.
The cookline and any fire-suppression system are protected before work starts, and the area sheeted.
Filters, canopy, plenum and extract fan degreased - a two-stage clean where the grease is baked on.
You get a dated certificate, before-and-after photographs and a recommended cleaning interval.
By cooking volume. A heavy line needs cleaning more often than a light one - TR19 Grease sets the interval by daily cooking hours, and we assess your grease loading and set a next-due date rather than guessing.
The whole system - filters, canopy, plenum, fan housing and impeller, and the accessible duct. Grease on the fan is usually what has actually killed the airflow, so filters alone rarely fix a hot, smoky kitchen.
No. We degrease around the nozzles and detection of a wet-chemical system without disturbing them, so both the extraction and the suppression are left working.
Yes - the High Street and St Mary's, the Swift crossing, and Magna Park in the Golden Triangle, and across the wider Leicestershire.
Yes. We work overnight, early mornings and closed days, at no extra charge for out-of-hours work, so the kitchen is ready for the next service.
Lutterworth was John Wycliffe's town on the old Watling Street, and today Magna Park, one of Europe's biggest distribution parks, sits beside it in the motorway Golden Triangle, its High Street inns and the park canteens feeding the trade. Left in place, that grease feeds flame and starves airflow. We work around service so the extraction is clean, certified and pulling properly before the next service.
We have stripped, degreased and certified commercial extraction to TR19 Grease since 2001, across Leicestershire and the UK. On a hard-frying line the job is the same every time: the whole system taken back, the fan balanced, and a certificate that satisfies your insurer and fire risk assessor.
Send us your cookline and frying hours and we will survey, strip, degrease and certify - across Leicestershire.
