Extraction Cleaning · Matlock
From the the Dale Road inns to the Crown Square cafes, Matlock cooks over open flame - and a greased-up canopy, filter and fan pull badly, run hot and add fire risk. We strip and degrease the whole system, canopy to fan, and certify it fire-safe.
Tell us about the canopy, filters and ducting in your Matlock kitchen and get a guide price straight away - no measuring, no site visit, no waiting.
Try the cost calculatorAcross Matlock, from the Dale Road inns to the Crown Square cafes, the cooklines all meet one test: service after service packing the canopy with grease. The kitchens differ; the grease does not.
In a food economy of 1,010 rated premises, a Matlock line loads canopy, filters and fan steadily until the grease sets - and then the hood stops capturing, the kitchen turns hot and smoky, and the fan sits as a fire risk over a live flame. We degrease the whole system so draw and fire safety come back together.
A degreased extraction is not just a compliance tick - your chefs feel it on the line. Restored airflow pulls the heat, smoke and grease-laden air off the cookline instead of leaving it in the kitchen, so the space is cooler to work in and the cooking smells stay out of the dining room.
It is measured and evidenced to TR19 Grease, with the fan the tell: when a Matlock kitchen goes hot and smoky, it is usually grease unbalancing the impeller, not the filters.
The standard on a commercial canopy. We strip, soak and scrape them back, and flag any that are warped or missing - the gap a warped filter leaves lets grease straight into the plenum.
Common on lighter lines and older canopies, and quick to clog solid. We clean what you run and advise where a baffle filter would serve a heavy frying line better.
On enclosed or recirculating systems. We service the stages, check the seals and tell you what needs replacing rather than cleaning.
Many cooklines carry a wet-chemical system built into the canopy. We degrease the filters, canopy and fan without disturbing the nozzles or detection - so you keep both defences.
Where a gas interlock ties the cookline to the extract, we work around it and leave it functioning, so the line cannot fire without the extraction running.
We check and clear accessible fire dampers in the run, so a damper that has to close in a fire is not seized solid with grease.
Typical jobs we handle, by sector and area - representative of the work we do, not named clients.
At a restaurant in Matlock, cooking a full menu, months of frying had packed the canopy and fan with grease and the draw had fallen away. We removed and soaked the baffles, degreased the canopy, plenum and fan, and cleaned the reachable duct on a closed day. The pull and the fire protection were back, with a certificate and photographs.
At a hotel in Matlock, running breakfast and dinner service for guests, a heavy line had loaded the canopy and fan housing and the extraction had gone weak. We cleaned the filters, canopy and baffles, scraped the duct, and degreased the fan housing and impeller overnight. The cookline drew properly again, certified with before-and-after photos.
We check the canopy, filters and fan, gauge the grease loading and how far the pull has dropped, and agree the scope.
The cookline and any fire-suppression system are protected and the area sheeted before work starts.
Filters, canopy, plenum and fan are degreased end to end - twice over where the grease has baked on hard.
You get a dated certificate, before-and-after photographs and a recommended cleaning interval.
On cooking hours. The heavier the line the sooner it needs doing - TR19 Grease bases the interval on daily cooking hours, so we assess your loading and put a next-due date on it rather than guess.
The whole system - filters, canopy, plenum, fan housing and impeller, and the accessible duct. Grease on the fan is usually what has actually killed the airflow, so filters alone rarely fix a hot, smoky kitchen.
No. We degrease around the nozzles and detection of a wet-chemical system without disturbing them, so both the extraction and the suppression are left working.
Yes - Crown Square and Dale Road, the Derwent and Hall Leys Park, and the trade units toward the A6, and across the wider Derbyshire.
Yes. We work overnight, early mornings and closed days, at no extra charge for out-of-hours work, so the kitchen is ready for the next service.
Matlock rose as a spa town on the Derwent below the gorge at Matlock Bath, now Derbyshire's county town, its Crown Square and Dale Road inns and cafes feeding the Peak District visitors. Left in place, that grease feeds flame and starves airflow. We work around service so the extraction is clean, certified and pulling properly before the next service.
We have stripped, degreased and certified commercial extraction to TR19 Grease since 2001, across Derbyshire and the UK. On a hard-frying line the job is the same every time: the whole system taken back, the fan balanced, and a certificate that satisfies your insurer and fire risk assessor.
Send us your cookline and frying hours and we will survey, strip, degrease and certify - across Derbyshire.
