Extraction Cleaning · Bebington
Bebington's cooklines - village restaurants, Port Sunlight tea rooms, Bromborough canteens - load canopy, filters and fan with grease. We strip and degrease the whole extraction system, canopy to fan, and certify it fire-safe to TR19 Grease.
Tell us about the canopy, filters and ducting in your Bebington kitchen and get a guide price straight away - no measuring, no site visit, no waiting.
Try the cost calculatorBebington cooks along the Wirral bank. The restaurants of the village, the tea rooms of Port Sunlight, the takeaways of New Ferry and the works canteens toward Bromborough all work their canopies through long days, and grease builds on the filters, up the plenum and into the fan faster than a nightly wipe reaches.
Within a Wirral food economy of 2,335 rated premises, a greased extraction gives itself away as always - a hot, smoky kitchen, a hood that has stopped drawing, caked filters and a fan sitting as a fire load over the flame. We strip, degrease and certify the whole system to TR19 Grease so the pull returns, and where the airflow has already gone it is the greased fan we put right.
Swapping filters treats the symptom; grease in the canopy, plenum and fan is what actually strangles the airflow. Clean the lot together and the cookline captures again, the kitchen runs cooler, and the fire risk over a live line comes down with it.
It is measured and evidenced to TR19 Grease, with the fan the tell: when a Bebington kitchen goes hot and smoky, it is usually grease unbalancing the impeller, not the filters.
The standard on a commercial canopy. We strip, soak and scrape them back, and flag any that are warped or missing - the gap a warped filter leaves lets grease straight into the plenum.
Common on lighter lines and older canopies, and quick to clog solid. We clean what you run and advise where a baffle filter would serve a heavy frying line better.
On enclosed or recirculating systems. We service the stages, check the seals and tell you what needs replacing rather than cleaning.
Many cooklines carry a wet-chemical system built into the canopy. We degrease the filters, canopy and fan without disturbing the nozzles or detection - so you keep both defences.
Where a gas interlock ties the cookline to the extract, we work around it and leave it functioning, so the line cannot fire without the extraction running.
We check and clear accessible fire dampers in the run, so a damper that has to close in a fire is not seized solid with grease.
Real jobs, described by sector and area - never by a client's name.
A works canteen toward Bromborough had loaded its canopy and slowed its fan until the kitchen ran hot at peak. We stripped and soaked the filters, scraped canopy and duct, and degreased the fan so the extraction pulled properly through the rush again.
A Bebington village restaurant's extraction had lost its draw - grease had reached the impeller. We cleaned the fan with the whole system so the airflow that returned was real, and left the certificate and photographs.
We check the canopy, filters and fan, gauge the grease loading and how far the pull has dropped, and agree the scope.
The cookline and any fire-suppression system are protected and the area sheeted before work starts.
Filters, canopy, plenum and fan are degreased end to end - twice over where the grease has baked on hard.
You get a dated certificate, before-and-after photographs and a recommended cleaning interval.
By cooking volume - TR19 Grease sets the interval by daily cooking hours, and we set a next-due date to your grease loading.
The whole system - filters, canopy, plenum, fan and impeller, and the accessible duct. The greased fan is usually the real cause of weak airflow.
No - we degrease around a wet-chemical system's nozzles and detection without disturbing them.
Yes - the village, New Ferry, Port Sunlight and Bromborough, and across Merseyside.
Yes - overnight, early mornings and closed days at no extra charge.
The canteens serving the Bromborough works and the Wirral International Business Park cook in volume for the shifts, some of the hardest-worked cooklines around Bebington. Left to load, their extraction runs hot and becomes a fire risk over the flame. We degrease the whole line so it keeps drawing and stays safe.
We have stripped, degreased and certified commercial extraction to TR19 Grease since 2001, across Merseyside and the UK. On a hard-frying line the job is the same every time: the whole system taken back, the fan balanced, and a certificate that satisfies your insurer and fire risk assessor.
Send us your cookline and frying hours and we will survey, strip, degrease and certify - across Merseyside.
