Extraction Cleaning · Churchdown
From the the village pubs to the parade cafes, Churchdown cooks over open flame - and a greased-up canopy, filter and fan pull badly, run hot and add fire risk. We strip and degrease the whole system, canopy to fan, and certify it fire-safe.
Tell us about the canopy, filters and ducting in your Churchdown kitchen and get a guide price straight away - no measuring, no site visit, no waiting.
Try the cost calculatorChurchdown cooks hard, and from the village pubs to the parade cafes every cookline faces the same test - service after service loading its canopy with grease. The settings vary; the grease does not.
Sitting inside a food economy of 950 rated premises, a Churchdown cookline loads its canopy, filters and fan steadily. Once the grease sets, the hood stops capturing at the line, the kitchen turns hot and smoky, and the caked filters and fan sit as a fire risk over a live flame. We strip and degrease the whole system so the airflow - and the fire safety - come back.
Swapping filters treats the symptom; grease in the canopy, plenum and fan is what actually strangles the airflow. Clean the lot together and the cookline captures again, the kitchen runs cooler, and the fire risk over a live line comes down with it.
It is measured and evidenced to TR19 Grease, with the fan the tell: when a Churchdown kitchen goes hot and smoky, it is usually grease unbalancing the impeller, not the filters.
The standard on a commercial canopy. We strip, soak and scrape them back, and flag any that are warped or missing - the gap a warped filter leaves lets grease straight into the plenum.
Common on lighter lines and older canopies, and quick to clog solid. We clean what you run and advise where a baffle filter would serve a heavy frying line better.
On enclosed or recirculating systems. We service the stages, check the seals and tell you what needs replacing rather than cleaning.
Many cooklines carry a wet-chemical system built into the canopy. We degrease the filters, canopy and fan without disturbing the nozzles or detection - so you keep both defences.
Where a gas interlock ties the cookline to the extract, we work around it and leave it functioning, so the line cannot fire without the extraction running.
We check and clear accessible fire dampers in the run, so a damper that has to close in a fire is not seized solid with grease.
Typical jobs we handle, by sector and area - representative of the work we do, not named clients.
At a primary school in Churchdown, cooking hot lunches at volume through term, the hood had stopped drawing cleanly and grease coated the filters, plenum and fan. We degreased the whole system - filters, canopy, plenum, fan and the accessible duct working around service. The pull and the fire protection were back, with a certificate and photographs.
At a hotel in Churchdown, running breakfast and dinner service for guests, the system was running hot and pulling poorly, grease built up from the filters to the fan. We degreased the whole system - filters, canopy, plenum, fan and the accessible duct on a closed day. The draw and fire protection were back; we left the photos and certificate for the file.
We survey the canopy, filters and fan and gauge the grease loading and how far airflow has dropped.
The line and any suppression system are protected and the area covered before we start.
The whole system is degreased - filters, canopy, plenum and fan - twice over where grease is baked on.
You get the certificate, the before-and-after photographs and a recommended re-clean date.
On cooking hours. The heavier the line the sooner it needs doing - TR19 Grease bases the interval on daily cooking hours, so we assess your loading and put a next-due date on it rather than guess.
The whole system - filters, canopy, plenum, fan housing and impeller, and the accessible duct. Grease on the fan is usually what has actually killed the airflow, so filters alone rarely fix a hot, smoky kitchen.
No. We degrease around the nozzles and detection of a wet-chemical system without disturbing them, so both the extraction and the suppression are left working.
Yes - the village centre and Chosen Hill, the parade shops, and the Golden Valley edge of the village, and across the wider Gloucestershire.
Yes. We work overnight, early mornings and closed days, at no extra charge for out-of-hours work, so the kitchen is ready for the next service.
Churchdown sits below Chosen Hill between Gloucester and Cheltenham, a large commuter village whose pubs and parade cafes feed the community. Left in place, that grease feeds flame and starves airflow. We work around service so the extraction is clean, certified and pulling properly before the next service.
We have stripped, degreased and certified commercial extraction to TR19 Grease since 2001, across Gloucestershire and the UK. On a hard-frying line the job is the same every time: the whole system taken back, the fan balanced, and a certificate that satisfies your insurer and fire risk assessor.
Send us your cookline and frying hours and we will survey, strip, degrease and certify - across Gloucestershire.
